Zetec Swap Write Up - Page 7 - Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum
Ford Focus Forum
HomeContact UsAbout UsGalleryDiscussion ForumsMarketplace


Go Back   Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum > Ford Focus Tech Discussions > Engine & Transmission Swap

Engine & Transmission Swap The place to chat about any engine and transmission swap.

Search This Forum | Image Search | Advanced Search    
FocusFest

Like Tree1Likes
Reply




 
LinkBack Thread Tools Display Modes
Old 06-27-2013, 09:02 AM   #61
REVOLT.BUILD.RISE
 
TheGlassMaker's Avatar
 
Join Date: Oct 2009
Fan#: 69510
Location: De Graff, OH
What I Drive: 97 Impreza coupe, 04 Mazda6

Posts: 8,424
Points 47,309, Level 100
Points: 47,309, Level: 100 Points: 47,309, Level: 100 Points: 47,309, Level: 100
Level Up 0% Completed
Level up: 0% Level up: 0% Level up: 0%
Forum Activity 0%
Activity: 0% Activity: 0% Activity: 0%
FF Reputation: 13 TheGlassMaker Great Standing Member
Buy-Sell-Trade Rating: (5)
SVT engine and drivetrain is completely different. All of it will need to swapped over. the full chassis harness, axles, engine, trans, fuel system, ect, ect....

It is possible I've never done it but a few on here has.
__________________
Do one thing every day that scares you. -Eleanor Roosevelt
TheGlassMaker is offline  
    Reply With Quote Quick reply to this message
Sponsored Links
Advertisement
 
Old 07-07-2013, 07:37 PM   #62
Focus Rookie
 
NuFazefocus's Avatar
 
Join Date: May 2013
Fan#: 115060
Location: Towanda, PA
What I Drive: 2002 white focus sedan

Posts: 17
FF Reputation: 1 NuFazefocus Good Standing Member
Buy-Sell-Trade Rating: (0)
I dont know where else fo post this.... i need an 03 ecu and wiring harness for zetec with manual trans
NuFazefocus is offline  
    Reply With Quote Quick reply to this message
Old 07-07-2013, 11:12 PM   #63
REVOLT.BUILD.RISE
 
TheGlassMaker's Avatar
 
Join Date: Oct 2009
Fan#: 69510
Location: De Graff, OH
What I Drive: 97 Impreza coupe, 04 Mazda6

Posts: 8,424
Points 47,309, Level 100
Points: 47,309, Level: 100 Points: 47,309, Level: 100 Points: 47,309, Level: 100
Level Up 0% Completed
Level up: 0% Level up: 0% Level up: 0%
Forum Activity 0%
Activity: 0% Activity: 0% Activity: 0%
FF Reputation: 13 TheGlassMaker Great Standing Member
Buy-Sell-Trade Rating: (5)
Quote:
Originally Posted by NuFazefocus View Post
I dont know where else fo post this.... i need an 03 ecu and wiring harness for zetec with manual trans
Post up here. You'll get a better response.

http://www.focusfanatics.com/forum/f...splay.php?f=34
__________________
Do one thing every day that scares you. -Eleanor Roosevelt
TheGlassMaker is offline  
    Reply With Quote Quick reply to this message
Sponsored Links
Advertisement
 
Old 07-25-2013, 10:06 AM   #64
Focus Rookie
 
NuFazefocus's Avatar
 
Join Date: May 2013
Fan#: 115060
Location: Towanda, PA
What I Drive: 2002 white focus sedan

Posts: 17
FF Reputation: 1 NuFazefocus Good Standing Member
Buy-Sell-Trade Rating: (0)
This swap has been such a headache. We finally got an ecu and harness for a m/t but its my understanding its still not a guarantee it will work even after flashing the ecu and reprogramming the keys...? is there anything else that would keep it from starting?
NuFazefocus is offline  
    Reply With Quote Quick reply to this message
Old 09-22-2013, 02:13 PM   #65
Focus Rookie
 
Join Date: Nov 2012
Fan#: 106526
Location: Hemet, CA
What I Drive: 1989 Ford Probe GT

Posts: 24
FF Reputation: 1 V3N0M951 Good Standing Member
Buy-Sell-Trade Rating: (0)
What part of the enginr harness is needed? Trying to get one right now, also fuel lines how far?
V3N0M951 is offline  
    Reply With Quote Quick reply to this message
Old 09-22-2013, 02:37 PM   #66
REVOLT.BUILD.RISE
 
TheGlassMaker's Avatar
 
Join Date: Oct 2009
Fan#: 69510
Location: De Graff, OH
What I Drive: 97 Impreza coupe, 04 Mazda6

Posts: 8,424
Points 47,309, Level 100
Points: 47,309, Level: 100 Points: 47,309, Level: 100 Points: 47,309, Level: 100
Level Up 0% Completed
Level up: 0% Level up: 0% Level up: 0%
Forum Activity 0%
Activity: 0% Activity: 0% Activity: 0%
FF Reputation: 13 TheGlassMaker Great Standing Member
Buy-Sell-Trade Rating: (5)
Fuel lines just the rubber hose that goes from the fuel rail to the fuel line on the fire wall. Plus that round silver thing.

The harness you'll need all of it. the two small harnesses on top of the engine and trans. Then the large harness that goes from the firewall into the passengerside fender area. It then continues into the car up under the dash just behind the glove compartment. Where it meets up with the ECU, then it goes down to the floor board and runs along the inside floor board and goes back to the fuel pump. Which you'll need to drop the tank to get to.
__________________
Do one thing every day that scares you. -Eleanor Roosevelt
TheGlassMaker is offline  
    Reply With Quote Quick reply to this message
Old 09-22-2013, 03:00 PM   #67
Focus Enthusiast
 
Join Date: Aug 2013
Fan#: 118287
Location: Logan, OH
What I Drive: 00 blue FF, 91 black Volks Jetta

Posts: 145
FF Reputation: 1 tryingtofixthis Good Standing Member
Buy-Sell-Trade Rating: (0)
and to just add on to what glassmaker said about the fuel lines, you can use a rubber tube split down thje middle length wise on one hale to slip around the fuel line then push it into the silver connector thing so you dont mess it up.(its got 4 little prongs inside that hold the lip of the fuel line)
__________________
Gasoline, Better burn it while we still can!
tryingtofixthis is offline  
    Reply With Quote Quick reply to this message
Old 09-22-2013, 05:14 PM   #68
Focus Rookie
 
Join Date: Nov 2012
Fan#: 106526
Location: Hemet, CA
What I Drive: 1989 Ford Probe GT

Posts: 24
FF Reputation: 1 V3N0M951 Good Standing Member
Buy-Sell-Trade Rating: (0)
I was reading that you can cut the fuel pump wires n solder em to the original connector? I got everything minus the power n ground terminal do I need the whole wire for it or just the terminals?
V3N0M951 is offline  
    Reply With Quote Quick reply to this message
Old 09-22-2013, 05:49 PM   #69
REVOLT.BUILD.RISE
 
TheGlassMaker's Avatar
 
Join Date: Oct 2009
Fan#: 69510
Location: De Graff, OH
What I Drive: 97 Impreza coupe, 04 Mazda6

Posts: 8,424
Points 47,309, Level 100
Points: 47,309, Level: 100 Points: 47,309, Level: 100 Points: 47,309, Level: 100
Level Up 0% Completed
Level up: 0% Level up: 0% Level up: 0%
Forum Activity 0%
Activity: 0% Activity: 0% Activity: 0%
FF Reputation: 13 TheGlassMaker Great Standing Member
Buy-Sell-Trade Rating: (5)
You can actually splice into the spi harness at the passenger seat just before it forks off to the shifter. From there back its the same harness.
__________________
Do one thing every day that scares you. -Eleanor Roosevelt
TheGlassMaker is offline  
    Reply With Quote Quick reply to this message
Old 09-22-2013, 07:55 PM   #70
Focus Rookie
 
Join Date: Nov 2012
Fan#: 106526
Location: Hemet, CA
What I Drive: 1989 Ford Probe GT

Posts: 24
FF Reputation: 1 V3N0M951 Good Standing Member
Buy-Sell-Trade Rating: (0)
ok just making sure i read right, as of the terminals what exactly has to be changed?
V3N0M951 is offline  
    Reply With Quote Quick reply to this message
Reply

Bookmarks & Social Networks

Quick Reply
Message:
Options

Register Now

In order to be able to post messages on the Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:
What I Drive
Year, color, and model of your car. Example: 2003 Focus Centennial Edition Sedan
Name
Your real name.
City
State
Country
Insurance
Please select your insurance company (Optional)

Log-in


Thread Tools
Display Modes

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On



All times are GMT -5. The time now is 12:48 AM.


Copyright 2002-2015 FocusFanatics.com. All Rights Reserved : : Advertise Information

Focus Fanatics Ford Focus Forum offers many fun ways for you to engage with other Ford Focus Owners from across the world. Whether it be about the aftermarket performance modifications, technical how-to's, European tuned suspension or awesome fuel economy similar to the Mazda CX-3, Audi S3, Mazda MX-5 Miata and Acura TLX. You can find all Ford Focus, Focus ST and Focus RS related information here. Join our Ford Focus discussion forums and chat with local Focus enthusiasts in your area. If you own other makes have a look at Challenger Hellcat Forum, Charger Hellcat Forum, Cadillac ATS-V Forum, Cadillac CTS-V Forum, Lexus RC-F Forum, Lexus GS-F Forum, Mercedes GLA Forum, Mercedes GLE Forum and Volvo XC90 Forum.




 

Search Engine Optimization by vBSEO 3.6.1