zx3 heater and overheating problem help! - Focus Fanatics
Ford Focus Forum
HomeContact UsAbout UsGalleryDiscussion ForumsMarketplace


Go Back   Focus Fanatics > Ford Focus Tech Discussions > General Technical Chat

General Technical Chat This section is for technical discussions relating to general maintenance, electrical issues, engine trouble, and recalls.

Search This Forum | Image Search | Advanced Search    
Ford Focus Tire & Wheels FocusFanatics Merchandise

Reply
 
Thread Tools Display Modes
Old 01-26-2013, 12:22 PM   #1
zx3mike
Focus Rookie
 
Join Date: Jan 2013
Fan#: 109107
Location: portland, OR
What I Drive: white 2000 zx3

Posts: 5
FF Reputation: 1 zx3mike Good Standing Member
Buy-Sell-Trade Rating: (0)
zx3 heater and overheating problem help!

So my zx3 heater will not blow on #4 hi seting,if i set it to defrost the a.c automaticly kicks on.
I have to turn it off every time,pluss almost no heat,and lack of horsepower untell i take it off defrost, car overheats in trafick unless i turn the a.c on? Then it cools back down fast,coolint is good and new t.stat,??? Any ideas? I think its a couple things but not sure whare to start


zx3mike is offline  
    Reply With Quote
Sponsored Links
Advertisement
 
Old 01-26-2013, 01:04 PM   #2
whynotthinkwhynot
Captain TMI
 
whynotthinkwhynot's Avatar
 
Join Date: Jan 2005
Fan#: 18416
Location: the armpit of TN, Memphis, TN
What I Drive: 05 ZXW; 02 Windstar; 13 C-Max SEL

Posts: 20,066
FF Reputation: 270 whynotthinkwhynot Outstanding Standing Memberwhynotthinkwhynot Outstanding Standing Memberwhynotthinkwhynot Outstanding Standing Member
Buy-Sell-Trade Rating: (1)
You have several problems let me see if I got this straight.

Blower will not work on any settings, or will not work on speed #4: You need a new fan control switch if the blower works on 1, 2, and 3. If the blower doesn't work on any speed, you should check the blower motor before replacing the switch. The blower motor itself might be bad.

AC comes on DEF vent setting: this is normal. The AC will come on whether the light comes on or not. This is because refrigeration systems pull moisture of the the air, and dry air on the inside of the windshield will clear fog faster than wet air at any temp. The AC also comes on when set to the DEF/FLR setting.

Car overheats at slow speeds or stopped with engine running, but cools off quickly when the AC is on: That is the engine cooling fan resistor that is the problem. Since you have a Zetec, it is also possible that the pigtail to the cooling fan resistor is also damaged. You should inspect both of these. The chance that these are damaged is more likely if the exhaust heat shield is removed, or a header is installed but not wrapped.

No heat: that could be multiple things. You should check your coolant level. I doubt it is a thermostat stuck open because I doubt it would overheat if it was stuck open. I'd fix this last. What you might end up having to do is drain the coolant, disconnect both heater hoses from the engine, then force water through the heater hoses until the water runs clear. I would force water through one direction, then put your water hose up to the other heater hose to force it through the opposite direction. You'll also want to keep an eye out on the floor under the passenger side to see if water is leaking from the air system. That would indicate a hole in the heater core. It might not be seeping through now because so much rust is clogging up the lower part of the heater core. Hopefully you'll force water through- see a chunk of crud come out, and not have any water on the floor inside the car.
__________________
Be eclectic.
---The Complete How-To Archive--

Moderating everything now, let me know if I can help.

Quote:
Originally Posted by the user formerly known as ZX3_Chick View Post
You're special aren't you.
whynotthinkwhynot is offline  
    Reply With Quote
Reply

Bookmarks & Social Networks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -5. The time now is 02:50 AM.


Copyright 2002-2014 FocusFanatics.com. All Rights Reserved : Terms of Use : Privacy Policy : Advertise Information : Site Map

Focus Fanatics Ford Focus Forum offers many fun ways for you to engage with other Ford Focus Owners from across the world. Whether it be about the aftermarket performance modifications, technical how-to's, European tuned suspension or awesome fuel economy similar to the Acura TLX or Fiesta ST. You can find all Ford Focus and Focus ST related information here. Join our Ford Focus discussion forums and chat with local Focus enthusiasts in your area.