How To: Adding an OEM Tachometer Cluster on a 2005-up - Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum
Ford Focus Forum
HomeContact UsAbout UsGalleryDiscussion ForumsMarketplace

Go Back   Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum > Ford Focus First Generation > MK1 Interior Mods & Upgrades

MK1 Interior Mods & Upgrades The place to chat about performance gauges, shifter knobs, custom interior paint, car seats or any interior upgrades for the 2000-2007 Focus.

Search This Forum | Image Search | Advanced Search    
FocusFest FocusFanatics Merchandise

Thread Tools Display Modes
Prev Previous Post   Next Post Next
Old 10-26-2005, 10:45 PM   #1
Focus Enthusiast
zxtunerdotcom's Avatar
Join Date: Feb 2005
Fan#: 19637
Location: murrieta, ca
What I Drive: 2005 Cloud 9 White ZX3 S

Posts: 333
FF Reputation: 1 zxtunerdotcom Good Standing Member
Buy-Sell-Trade Rating: (0)
How To: Adding an OEM Tachometer Cluster on a 2005-up

How to change Speedo Clusters from Non-Tach style to Tach style on a 2005 in 10 Easy Steps:

Estimated time: 30 minutes max.

1. Purchase a Speedo/Tach. In 2005, the instrument clusters were changed in wiring and construction, making it mandatory that a 2005-2006 cluster be used (2000-2004 will not work). I purchased my cluster at for $85 shipped.

2. Disconnect the negative cable on your car's battery.

3. Tools needed: 7mm combination wrench, 7mm and 8mm sockets w/ ratchet or nut driver.

4. With the 8mm socket, remove the two bolts on the lower dash trim, at about steering column level. The whole panel does not to be removed, so you can leave the lower hood cable, OBD2 plug, and attaching bolts alone.

5. Pry the lower trim panel back on the far left corner to gain access to the single bolt securing the dash trim, located right below the headlight switch.

6. Remove the bolt with a 7mm combination wrench.

7. Now it's time to remove the instrument trim panel - it just tugs loose. Once it's free from it's clips, disconnect the rubber flap that sits between the steering column and the trim panel. It's held on with rubber nipples that fit in slots on the trim panel - just pull them out one at a time.
Then, disconnect the electrical plug on the Trunk release button. The button pops out easily too. The trim panel should now be ready to lift off.

8. All that's left now is 1 plug and 4 bolts. Remove the 4 bolts attaching the cluster to the dash, and disconnect the plug. The plug latches like a basket handle - just pry up the black handle and the plug will seperate from the cluster. To plug it back on, push the handle back down and it will suck the plug onto the speedo cluster's socket.

9. I found that if your car does not have ABS or Traction Control, the cluster will illuminate the traction control, abs, and brake warning lamps whenever the key is on. To avoid staring at them lit up all the time, I remedied this by removing the upper lens and bezel from the actual speedo cluster and applying black tape over the offending led bulb lenses. When I put the bezel back on, it became impossible to tell they were permanently lit. The only down side I can see by doing this is the Brake warning lamp is now inoperable so if you're one of those who drives away with your emergency brake on or you don't check your brake fluid level periodically, this mod might not be for you.

10. It's time to install the cluster! Just put everything back on in the order it came off and you'll be done! Go enjoy!


Last edited by zxtunerdotcom; 10-26-2005 at 10:52 PM.
zxtunerdotcom is offline  
    Reply With Quote

Bookmarks & Social Networks

Quick Reply

Register Now

In order to be able to post messages on the Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Please enter a password for your user account. Note that passwords are case-sensitive.
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:


Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.

Thread Tools
Display Modes

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

All times are GMT -5. The time now is 08:23 PM.

Copyright 2002-2014 All Rights Reserved : Privacy Policy : Advertise Information

Focus Fanatics Ford Focus Forum offers many fun ways for you to engage with other Ford Focus Owners from across the world. Whether it be about the aftermarket performance modifications, technical how-to's, European tuned suspension or awesome fuel economy similar to the Audi S3, Ford Fusion and Acura TLX. You can find all Ford Focus and Focus ST related information here. Join our Ford Focus discussion forums and chat with local Focus enthusiasts in your area. Challenger Hellcat - Charger Hellcat