Battery relay clicking, loss of all electrical, then it returns - Focus Fanatics
Ford Focus Forum
HomeContact UsAbout UsGalleryDiscussion ForumsMarketplace



Go Back   Focus Fanatics > Ford Focus Tech Discussions > General Technical Chat

General Technical Chat This section is for technical discussions relating to general maintenance, electrical issues, engine trouble, and recalls.

Search This Forum | Image Search | Advanced Search    
FocusFest Ford Focus Tire & Wheels FocusFanatics Merchandise

Reply
 
Thread Tools Display Modes
Old 07-09-2013, 03:50 PM   #1
jmkma
Focus Rookie
 
Join Date: Jun 2012
Fan#: 100627
Location: Harwich, MA
What I Drive: 2005 silver zx4

Posts: 6
FF Reputation: 1 jmkma Good Standing Member
Buy-Sell-Trade Rating: (0)
Battery relay clicking, loss of all electrical, then it returns

I have had this intermittent problem for a couple of years. I have found similar problems on the web, but no solution.

While driving, battery relay under dash starts to click loudly, all lights on dash start blinking, the engine will stutter like it is dying, but usually keeps running. Occasionally if you shut the car off while this is happening it will not restart. In fact it is like the battery has been disconnected. No courtesy lights, radio, horn, switches - everything is completely dead. If you play around with light switches, hitting brakes, turning ignition off and on, etc. Elecricity will magically reappear. It will start right up and run fine until the next time it happens. Occasionally when this happens what I think is an idle selonoid or something in front of the engine will click as well as the relay.

Have replaced battery, alternator and the clicking solenoid in engine compartment (I can;t remember what it is called but the new one clicks randomly as well), checked grounds and alternator leads. Like I mentioned earlier, there are a lot of posts of people having this problem, but no solution. I am giving this car to my daughter and woudl like to get it corrected. I have no interest in bringing it to a dealer as it appears no dealer ever succesfully fixed this problem for all the other people that had it and I have a limited budget.

Is there anyone who had this problem and was able to determine what caused it and how to fix it?

This was probably the last Ford for me - I've lived for a couple of years with an unreliable car (was purchased new) and find a problem like this unacceptable. I can understand an occasional one-off crazy problem, but a lot of people have had this issue so there must be a common problem.


jmkma is offline  
    Reply With Quote
Sponsored Links
Advertisement
 
Old 07-09-2013, 04:59 PM   #2
1turbofocus
FF Affiliate
 
1turbofocus's Avatar
 
Join Date: Oct 2003
Fan#: 1123
Location: Belmont, NC
What I Drive: 2000 ZX3 / 2002 SVT Turbocharged

Posts: 21,427
FF Reputation: 153 1turbofocus Excellent Standing Member1turbofocus Excellent Standing Member
Buy-Sell-Trade Rating: (28)
My guess would be your small ground wires to the left of your Batt and on inner fender well and the small wires going to the post on your Batt , there is a few of them and I would remove them all , sand them and replace them to see if that helps , it did one customers car I was working on

Tom
__________________
Focus-Power: Your #1 Source for Ford Focus Speed, Tuning & Performance!

Customer Support
AIM: hpdyno
Email: hpdyno@aol.com
Phone: 704-249-3745
Site: focus-power.com

Elder 1turbofocus
1turbofocus is offline  
    Reply With Quote
Old 07-10-2013, 12:06 PM   #3
jmkma
Focus Rookie
 
Join Date: Jun 2012
Fan#: 100627
Location: Harwich, MA
What I Drive: 2005 silver zx4

Posts: 6
FF Reputation: 1 jmkma Good Standing Member
Buy-Sell-Trade Rating: (0)
Thanks Tom, I will try that this weekend.
jmkma is offline  
    Reply With Quote
Old 07-13-2013, 12:34 PM   #4
ligardner
Focus Jr. Enthusiast
 
Join Date: Feb 2006
Fan#: 32567
Location: Alpharetta, Georgia, United States
What I Drive: 02 Focus LX; 05 Focus ZX4; 02 Wago

Posts: 49
FF Reputation: 1 ligardner Good Standing Member
Buy-Sell-Trade Rating: (0)
Hi,
This is a familiar story. My daughter has a 2005 Focus with the same issues: relay clicking, dash lights flicker, radio loses stations, headlights went crazy once . I knew it was some type of bad ground but she was too far away for me to help her. She finally located a small shop in NW Tennessee that diagnosed the problem. Can't tell you the name of the part, but it near the PCM and it was corroded. They replaced it and that fixed it. After two years of living with this. When she return home I'll ask her the name of that part.

-Lytt
ligardner is offline  
    Reply With Quote
Old 08-18-2013, 07:45 PM   #5
NC-Mike
Focus Jr. Enthusiast
 
Join Date: Aug 2012
Fan#: 103054
Location: Matthews, NC
What I Drive: 2013 Siver Ingot ST Base

Posts: 35
FF Reputation: 1 NC-Mike Good Standing Member
Buy-Sell-Trade Rating: (0)
Quote:
Originally Posted by ligardner View Post
Hi,
This is a familiar story. My daughter has a 2005 Focus with the same issues: relay clicking, dash lights flicker, radio loses stations, headlights went crazy once . I knew it was some type of bad ground but she was too far away for me to help her. She finally located a small shop in NW Tennessee that diagnosed the problem. Can't tell you the name of the part, but it near the PCM and it was corroded. They replaced it and that fixed it. After two years of living with this. When she return home I'll ask her the name of that part.

-Lytt
Please do, I am having much the same issue.

TIA.
NC-Mike is offline  
    Reply With Quote
Reply

Bookmarks & Social Networks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -5. The time now is 12:58 AM.


Copyright 2002-2014 FocusFanatics.com. All Rights Reserved : Terms of Use : Privacy Policy : Advertise Information : Site Map

Focus Fanatics Ford Focus Forum offers many fun ways for you to engage with other Ford Focus Owners from across the world. Whether it be about the aftermarket performance modifications, technical how-to's, European tuned suspension or awesome fuel economy similar to the Acura TLX or Fiesta ST. You can find all Ford Focus and Focus ST related information here. Join our Ford Focus discussion forums and chat with local Focus enthusiasts in your area.