What causes my coil pack to crack. - Focus Fanatics
Focus Fanatics Ford Focus Forums
HomeContact UsAbout UsGalleryDiscussion ForumsMarketplace



Go Back   Focus Fanatics > Ford Focus Tech Discussions > General Technical Chat

General Technical Chat This section is for technical discussions relating to general maintenance, electrical issues, engine trouble, and recalls.

Search This Forum | Image Search | Advanced Search    
FocusFest Ford Focus Tire & Wheels FocusFanatics Merchandise

Reply
 
Thread Tools Display Modes
Old 11-16-2012, 05:00 AM   #1
markmann1
Focus Rookie
 
Join Date: Nov 2012
Fan#: 106315
Location: Cincinnati, OH
What I Drive: 2000 SE Black

Posts: 3
FF Reputation: 1 markmann1 Good Standing Member
Buy-Sell-Trade Rating: (0)
What causes my coil pack to crack.

What causes my coil pack to crack. I have a 2000 Focus with a DOHC engine. I have new plugs, wires, alternator and battery. I have also changed the coil pack mount. The car runs for a short time then boom the coil pack cracked and car dies. This has happened 4 times.


markmann1 is offline  
    Reply With Quote
Sponsored Links
Advertisement
 
Old 11-16-2012, 08:39 AM   #2
6SPD_soul
Focus Addict
 
6SPD_soul's Avatar
 
Join Date: Feb 2008
Fan#: 53637
Location: Soldiers Grove, WI
What I Drive: 2003 Comp Orange EAP SVT

Posts: 1,468
FF Reputation: 24 6SPD_soul Great Standing Member
Buy-Sell-Trade Rating: (1)
I'm pretty sure the cracking is actually the spark going to ground through the coil pack body, for this to happen there'd have to be really high resistance somewhere in the wires or plugs, or your wire routing is not right. To begin with I'd ohm the plug wires and make sure none of them are open, resistance will be in thousands of ohms but probably shouldn't be higher than 5K or so given the length of the wires. I have Bosch wires and they were all at 2500 or so when new.

Did this happen once and then you replaced the wires and plugs and it keeps happening to brand new coil packs?

EDIT: One other thing to check is all the wiring going to the coil pack, these wires are known to break and cause problems, so give that a good visual inspection.

Last edited by 6SPD_soul; 11-16-2012 at 09:46 AM.
6SPD_soul is offline  
    Reply With Quote
Old 11-16-2012, 09:49 AM   #3
freemind
Vince your Moderator
 
freemind's Avatar
 
Join Date: Jul 2009
Fan#: 67513
Location: Seattle, WA
What I Drive: 2002 ZX3 and a 2010 Focus SE (Work)

Posts: 3,602
FF Reputation: 20 freemind Great Standing Member
Buy-Sell-Trade Rating: (17)
^This
__________________
133whp-126ftlbsTQ Eclipse CD8443,JBL Px300.4, JBL GTO7001, PPI 356cs, JBL p1024(Hooray!) SubThump enclosure, RAAmat BXT, Damplifier Pro

Hatch Nation #140
Caeci caecos ducentes
freemind is offline  
    Reply With Quote
Old 11-16-2012, 03:56 PM   #4
markmann1
Focus Rookie
 
Join Date: Nov 2012
Fan#: 106315
Location: Cincinnati, OH
What I Drive: 2000 SE Black

Posts: 3
FF Reputation: 1 markmann1 Good Standing Member
Buy-Sell-Trade Rating: (0)
What causes my coil pack to crack.

Quote:
Originally Posted by 6SPD_soul View Post
I'm pretty sure the cracking is actually the spark going to ground through the coil pack body, for this to happen there'd have to be really high resistance somewhere in the wires or plugs, or your wire routing is not right. To begin with I'd ohm the plug wires and make sure none of them are open, resistance will be in thousands of ohms but probably shouldn't be higher than 5K or so given the length of the wires. I have Bosch wires and they were all at 2500 or so when new.

Did this happen once and then you replaced the wires and plugs and it keeps happening to brand new coil packs?

EDIT: One other thing to check is all the wiring going to the coil pack, these wires are known to break and cause problems, so give that a good visual inspection.
All brand new Bosh wires, plugs. yes it happens to brand new coil pack. Brand new alternater and die hard battery.
markmann1 is offline  
    Reply With Quote
Old 11-19-2012, 03:19 AM   #5
amc49
Focus Fanatic
 
Join Date: Mar 2012
Fan#: 96610
Location: Fort Worth, TX
What I Drive: 00 wagon, 02 sedan both zetec atx

Posts: 3,525
FF Reputation: 19 amc49 Great Standing Member
Buy-Sell-Trade Rating: (0)
Are you using $15 Amazon coils that have uneven bottoms to crack when tightened down? Try also not tightening so much, they really don't have to be that tight. Plastic, you know. People around here love to crack the stat housings too, again, plastic.

Why did you change the coil mount? If not dead flat the out of plane (say one corner high or low) will crack coil when tightened down.

The longterm cracking on these that normally occurs after long periods of time is from temperature.
amc49 is offline  
    Reply With Quote
Old 11-19-2012, 04:16 AM   #6
markmann1
Focus Rookie
 
Join Date: Nov 2012
Fan#: 106315
Location: Cincinnati, OH
What I Drive: 2000 SE Black

Posts: 3
FF Reputation: 1 markmann1 Good Standing Member
Buy-Sell-Trade Rating: (0)
Quote:
Originally Posted by amc49 View Post
Are you using $15 Amazon coils that have uneven bottoms to crack when tightened down? Try also not tightening so much, they really don't have to be that tight. Plastic, you know. People around here love to crack the stat housings too, again, plastic.

Why did you change the coil mount? If not dead flat the out of plane (say one corner high or low) will crack coil when tightened down.

The longterm cracking on these that normally occurs after long periods of time is from temperature.
All new Two Ford Motocraft coil packs, Two Autozone Durolast. Got to be a short in the wireing or some thing else. Hopens with in 5 miles on test drive.
markmann1 is offline  
    Reply With Quote
Reply

Bookmarks & Social Networks

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -5. The time now is 07:00 AM.


Copyright 2002-2014 FocusFanatics.com. All Rights Reserved : Terms of Use : Privacy Policy : Advertise Information : Site Map

Focus Fanatics Ford Focus Forum offers many fun ways for you to engage with other Ford Focus Owners from across the world. Whether it be about the aftermarket performance modifications, technical how-to's, European tuned suspension or awesome fuel economy similar to the Acura TLX. You can find all Ford Focus related information here. Join our Ford Focus discussion forums and chat with local Focus enthusiasts in your area.