Focus Fanatics

Focus Fanatics (http://www.focusfanatics.com/forum/index.php)
-   Focus Tuning Chat (http://www.focusfanatics.com/forum/forumdisplay.php?f=79)
-   -   Tuning for MPG Gains (http://www.focusfanatics.com/forum/showthread.php?t=281154)

nos2006 03-02-2012 02:14 PM

Tuning for MPG Gains
 
First off, I just want to make it clear that I'm looking for real numbers, not speculation...

I have an '04 ZX3 w/ 2.3 and basically just have bolt ons including a long-tube header. The car doesn't really run perfectly smooth (though this is partially from the BSD I'm sure), and I know the right thing to do is to get it tuned to run better, but I'm on a really tight budget. So I'm looking for numbers for me to compare...

1. What is the cost of a 87 octane tune that will smooth out performance and increase MPGs?

2. For those who have been tuned with basic bolt ons (especially for those with their cat removed), what were the before/after MPGs with the same modifications (except the tune obviously)?

I want to look into a tune, but only if it's a good financial investment for me. If it's going to take me 15000 miles to make back my money from the tune on gas mileage alone, it's not worth it to me. And I think this is going to be difficult considering the best MPG I've gotten on this setup is somewhere around 36. Again, I know I'm looking at this wrong because the health of the car is the most important factor, but student loans are a bitch.


Thanks in advance!

1turbofocus 03-02-2012 03:05 PM

Building a new engine would be a itch as well LOL when you change the header and take out the CAT you change a lot of the fueling among other things , engine safety sould be your first worry , then MPG

36 as you are now ? forget about any gains from a tune that that is killer mpg

The MPG tuning that I do most come back telling me 0 to 2.5 depending on how they drive , you alse get safety and better over all driveability

Tom

jetrinka 03-03-2012 12:50 PM

Get a tune. When I had my 2.3 I had a header on it and ran it like that without a tune for a week and it just didn't feel right. Got a tune on it and everything smoothed out. Car felt much better afterwards.


All times are GMT -5. The time now is 10:35 PM.


http://www.focusfanatics.com/aboutus/copyright.asp