Focus Fanatics

Focus Fanatics (http://www.focusfanatics.com/forum/index.php)
-   Autocross Racing (http://www.focusfanatics.com/forum/forumdisplay.php?f=97)
-   -   real racing/beaverun (http://www.focusfanatics.com/forum/showthread.php?t=16659)

garyk 06-14-2004 09:49 AM

real racing/beaverun
 
well squirt finally did it. after fridays tsunami conditions for practice (open track for SEVEN! hours) and only running 1:22's with dying fuel pump, it did not look promising. sat. dawned clear and cool. enduro went off at 3:30, pitted at 4:38 with corded tire while in 3rd. went out on fresh rubber and car died on back straight and coasted for 1/2 mile. figured that was it until it caught again. amazingly we out lasted almost everyone else and despite losing the power steering at the end took a second.

Egz 06-14-2004 10:39 AM

Some like it wet:
http://members.cox.net/jeggert4/images/gary-wet.jpg

Some like it hot:
http://members.cox.net/jeggert4/images/gary-dry.jpg

WD40 06-14-2004 12:45 PM

Nice job, Gary. [thumb]
Did you find the culprit that caused the engine to die?
And, what happened to the power steering?

garyk 06-14-2004 12:59 PM

dying engine
 
we think there were 3 separate things going on. 1st fuel pump was dying causing sputter on uphills. fuel mileage (!) went way up with new pump we found sat a.m. at dealer about 22 miles away. however still cut out every time i caught the rumble strip in turn 6 leading us to think there is also a short somewhere. and to top that off, we may have water in the tank from refueling in torrential rain friday, that may have gotten into fuel cans. will no more after this weekend at vir. and power steering pump has leak on high pressure side. its not really meant to run hours on end at 5 to 7 thousand rpm! back to fuel pump-i was using a 1/4 tank for every 1/2 hour prctice friday in the rain when i was only running around 1:22 laps and keeping speed to no more than 100 on the straights due to aquaplaning issues on lousy tires. in saturdays race, was running a best of 1:12 and seeing 110-115 at times. used only 1/2 a tank for the race that ran over an hour. so though replacing it did not cure all problems, at least i was back to my usual 10 mpg at race speed.

WD40 06-14-2004 02:33 PM

power steering pump has leak on high pressure side.
So, the leak is at the pump itself?
Just asking, as during my first oil change I found THIS on my rack and pinion.[?|]

at least i was back to my usual 10 mpg at race speed.
Holy Cow! Maybe I better just stick to short ~2:00min AutoCross races.

Too bad about the fuel pump, though it does sound like electrical, not mechanical problem.
Personally, I hate trying to track down electrical gremlins.
Good luck!

garyk 06-14-2004 02:58 PM

well
 
i also hate electrical gremlins. have a feeling that its a loose ground somewhere. keep in mind, my battery is in the back, making things interesting with lots of extra wire. on the p/s-the eastern director of svtoa came out for the race. had same problem w/his. he replaced the line and still had leak. turns out ford, in its infinite wisdom, doesn't send the teflon outer seal with the line thats needed for repair. talked to one of our techs this a.m. and he said the seals go frequently on them. hopefully seal will be here tomorrow and we'll see if that fixes it. we are going to modify the pump to slow it down (basically take out the spring and cut 25% off) and run aeroquip lines soon. oops, sorry-no leak is in line or seal, not pump.

Egz 06-14-2004 07:09 PM

http://members.cox.net/jeggert4/garyk.avi
1.5Mb

Encoded with DivX 5.11
Used my cheap little digi cam, so not the best quality. I tried to clean it up.

viney266 06-15-2004 02:03 PM

I haven't been to beaverrun yet, looks like a wide track....lots of quardrail ( body shiver). Those small little cars like the rain ?!

WD40 06-15-2004 02:12 PM

Egz:
Does that clip have video?
I'm only getting the audio.
Sounds cool, but it would be nice to see.[;)]

garyk 06-15-2004 02:21 PM

well
 
bill, that little car loves the rain. that track is so new that adhesion is amazing. i put a self imposed limit of 95 on the back kinks and 100 on the front straight friday. above that i tended to aquaplane. i would have loved rain for the race. helps me with the higher power rwd cars. actually, adhesion was too good in the dry-ruined 3 v700 kuhmo race tires. down to the cord. and wd40-all i can get is the audio also. i would be more fustrated if i did not have an in car vid of the whole race. still would like to see it from the outside.


All times are GMT -5. The time now is 10:16 PM.


http://www.focusfanatics.com/aboutus/copyright.asp