Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum - Reply to Topic
Ford Focus Forum
HomeContact UsAbout UsGalleryDiscussion ForumsMarketplace


Go Back   Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum > Ford Focus Tech Discussions > General Technical Chat > 2001 Focus Not Start

General Technical Chat This section is for technical discussions relating to general maintenance, electrical issues, engine trouble, and recalls.

Search This Forum | Image Search | Advanced Search    
Ford Focus Tire & Wheels FocusFanatics Merchandise

Thread: 2001 Focus Not Start Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
07-19-2013 02:02 PM
MikeD83 Grounds look ok cleaned up the contact points and reattached not sure about the cable conditions. I checked the first four to five inches from the battery there wasn't any melting. But i agree it looking like the wiring to the starter must be bad somewhere along the line to not give it enough juice to start.
07-19-2013 01:47 PM
amc49 Don't be so sure of that. Nowadays you never know. They resell plenty of garbage the last guy before you just screwed up. BTDT...........

Battery sounds fine.

Sounds like you have power right to starter but not enough 'ooomph' to kick it over. Cable or terminal condition, engine grounds. The positive cable on these commonly goes bad under the insulation to be able to cause that. What does starter wire attachment area look like? They commonly melt inside the plastic to screw up too.

If neutral switch you wouldn't get the click, bad switch stops power from getting that far.
07-19-2013 01:26 PM
MikeD83 Well replaced the neutral safety switch, that didn't do it. But I got under there at this point and hit the starter with a hammer and the car started. However once turned off car wouldn't restart. This is a new starter so I know the problem isnt actually with that part.
07-19-2013 10:48 AM
MikeD83 Also doing some reading on the neutral safety switch can interrupt the starter from engaging. Is this a possibility as well, as the starter will click when the key is turned but will not engage?
07-19-2013 10:36 AM
MikeD83 Just had the battery load tested like you suggested amc49 CCA is at 666 and running at 12.7 volts. Started checking the wiring to starter and I will check the ground as well.
07-16-2013 01:30 PM
amc49 Power supply to starter, or, cable condition. Probably what it was all along...........need to check main engine ground too.

I see nothing still of battery load tested. I replaced plenty of crap batteries that failed in less than a year, often with people who insisted on buying the too cheap (less CCA) battery. You play, you pay................Battery needs load test at correct CCA. Could easily cause that. In heat like now our battery replacements went up like 400%.
07-16-2013 12:35 AM
MikeD83
2001 Ford Focus 16v Zetec No Start Continued...

Posted last week sometime and got some good advice on where to start. Replaced the ignition relay, starter, and alternator. Car still will not turn over. The key turns, and all I get is one click from the engine compartment. Looking for some more advice on what could be causing this. Thanks.
07-09-2013 07:27 PM
UnbridledCarnage moving ya to tech chat for more help
07-09-2013 06:33 PM
MikeD83 I have the zetec engine, alternator is pretty easy to get to. I'll get it taken off tomorrow, hope its the alternator I really don't feel like dealing with a short somewhere.
07-09-2013 06:10 PM
crazy_urn
Quote:
Originally Posted by MikeD83 View Post
Thanks guys ill get the alternator checked next then. Didn't notice a battery light but just checked it is on when the key is turned over after the rest of the dash light go out. The battery is fairly new. Funny though that the starter tested bad as well.
The starter may have been good enough to start the car, but not to pass the test... Quite possible with 12 year old parts....

If you find the alt is bad, make sure you have the battery tested after it is replaced. as Gav-O pointed out, dying alternators can be hell on batteries, even new ones.

By the way, what engine do you have in your focus?

I don't know about the zetec, but on the SPI the alt. is a real easy swap. hardest part is getting the accessory belt on at the end. Might be a good idea to check your belt tensioner while you have the belt off.
This thread has more than 10 replies. Click here to review the whole thread.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 05:39 AM.


Copyright 2002-2014 FocusFanatics.com. All Rights Reserved : Privacy Policy : Advertise Information

Focus Fanatics Ford Focus Forum offers many fun ways for you to engage with other Ford Focus Owners from across the world. Whether it be about the aftermarket performance modifications, technical how-to's, European tuned suspension or awesome fuel economy similar to the Audi S3, Ford Fusion and Acura TLX. You can find all Ford Focus and Focus ST related information here. Join our Ford Focus discussion forums and chat with local Focus enthusiasts in your area. Challenger Hellcat - Charger Hellcat