|05-23-2013 01:57 PM|
|cheap sleeper||I did my pcv without removing anything, not even the manifold shield. Take a good look around it, and use some brain powaaah!! I went from underneath the car and had it swapped in a couple of minutes of effort.|
|05-22-2013 12:26 PM|
|CriticalMass||Odd. The Fuel Filter is supposed to be located within the gas tank on the 2009 Focus? I think it was in the owner's manual, it's been a while, so I can't remember where i read it.|
|02-12-2013 11:28 AM|
|02-10-2013 10:44 PM|
|jetrinka||I really don't understand how you could get the valve out without taking the intake off. The valve is held into the breather on the block by a strange built in clip that I had issues with even with the manifold off. I could see doing the hose with the manifold on perhaps, but the valve, no way.|
|02-10-2013 10:06 PM|
|whynotthinkwhynot||That was what he said he used to re-install the PCV on a Duratec. I don't know how he did it exactly. A dab of oil on the inside of the hose makes it slip on easier. I've looked- it might be possible, but in my case it's not damaged so I'm not messing with it. I am removing my intake manifold to replace it due to tumble flap issues, and I'll do it and the thermostat while it's off.|
|02-10-2013 08:06 PM|
I get that, but how do you reinstall the hose?
|02-10-2013 04:16 PM|
The Zetec PCV has tons of threads on it. The low idle problem comes from collapsing elbows or the whole hose collapsing- in that car, with that engine. There have been no low idle issues with Duratec PCV hoses- only difficulty reaching the line.
One FF had luck with a long angled pair of needle nose pliers. No intake removal required.
|02-10-2013 03:12 PM|
* PCV valve hose seems to be a common problem...even at a early age*
I'll report back with my findings.
|02-03-2013 10:57 PM|
|01-31-2013 09:25 PM|
I also have the same problem. 34k on the 09 Focus. The only thing that's due on this car is the Fuel filter. I don't want to start throwing money...its too early for this car. No CEL.
I've dealt with 200k miles engines...and by far the Focus is the worst.
|This thread has more than 10 replies. Click here to review the whole thread.|