Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum - Reply to Topic
Ford Focus Forum
HomeContact UsAbout UsGalleryDiscussion ForumsMarketplace


Go Back   Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum > Ford Focus Tech Discussions > General Technical Chat > "How To"....repair a seat belt that's slow to retract.

General Technical Chat This section is for technical discussions relating to general maintenance, electrical issues, engine trouble, and recalls.

Search This Forum | Image Search | Advanced Search    
Ford Focus Tire & Wheels FocusFanatics Merchandise

Thread: "How To"....repair a seat belt that's slow to retract. Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
03-09-2009 06:52 PM
tukaniSVT Nice little write ... Mine aren't bad yet ... but that is good to know.

-Ray-
03-09-2009 03:28 PM
bluefront ^^^^^Yeah it's the same. A little pin on the outer trim piece that aligns with a hole in the upper belt adjuster mechanism. It's easy to do, but you might not notice it.
03-09-2009 02:09 PM
myfocusrocks Also, what you REALLY need to watch out for... is you HAVE to line up the plastic trim piece the belt goes through just perfect into the little hole on the mechanism (the part that allows you to adjust the height it sits on the shoulder) or the belt wont retract at all. I figured that out the hard way when I took the trim off to remove my rear door panel. I thought the belt itself was messed up, and it was under warranty, so I took it to a dealer, they got me a new belt... but the only thing wrong was that I didnt align it back up right. Once you get the trim off, you will see what Im talking about. At least, this is how it is in my ZX3, not sure about the sedan/ZX5/wagon.
03-09-2009 02:04 PM
niko Thanks bluefront!

I'm not sure if that is what is wrong with mine or not, my drivers side really does not want to retract anymore. But I have a ZX3, so i don't know if it has the intermediate belt loop or not.

-niko
03-08-2009 05:53 PM
pistolgripbmx I'll have to check into that, my passenger side doesn't retract back by itself. Mine might have a bigger problem but I may as well try this first.

Good job!
03-08-2009 05:42 PM
bluefront
"How To"....repair a seat belt that's slow to retract.

My '06 had slow retracting front seat belts.....I almost had to push the belt to get it to retract all the way. To repair this the book would tell you to disconnect the battery. But since I'm not actually unhooking any wires, or removing the retractor itself, I didn't do it.

Start by removing the trim pieces that cover the belt.....I had to remove four total. There are other how-to's describing this. It's fairly easy. Get it to the point of this first picture.



The problem was gunk/crap build-up on the center belt loop...visible in this photo...



That loop comes off the body easily by hand, and then comes off the belt. I had to scrape and use #400 sandpaper to get the thing clean.



I gave a light spray with a dry silicone, then put it back on.



The upper belt loop is plastic, and cannot be removed from the belt. Mine was fairly clean. But I carefully cleaned it with a mild solvent. Be careful not to get the belt dirty.



So there you go.....the belt now pulls itself back in without any help, like it was new.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 09:18 AM.


Copyright 2002-2014 FocusFanatics.com. All Rights Reserved : Privacy Policy : Advertise Information

Focus Fanatics Ford Focus Forum offers many fun ways for you to engage with other Ford Focus Owners from across the world. Whether it be about the aftermarket performance modifications, technical how-to's, European tuned suspension or awesome fuel economy similar to the Audi S3, Ford Fusion and Acura TLX. You can find all Ford Focus and Focus ST related information here. Join our Ford Focus discussion forums and chat with local Focus enthusiasts in your area. Challenger Hellcat - Charger Hellcat