Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum - Reply to Topic
Ford Focus Forum
HomeContact UsAbout UsGalleryDiscussion ForumsMarketplace


Go Back   Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum > Ford Focus Tech Discussions > General Technical Chat > How-To: Replace the Fuel Pump (56k death)

General Technical Chat This section is for technical discussions relating to general maintenance, electrical issues, engine trouble, and recalls.

Search This Forum | Image Search | Advanced Search    
Ford Focus Tire & Wheels FocusFanatics Merchandise

Thread: How-To: Replace the Fuel Pump (56k death) Reply to Thread
Title:
  
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now

In order to be able to post messages on the Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Additional Options
Miscellaneous Options

Topic Review (Newest First)
11-11-2014 11:30 AM
rhowe I did mine with a full tank, thru the floor.
11-10-2014 08:49 PM
seraniko but the fuel pump is dead.
11-10-2014 05:12 PM
carzts drive around till u see the low fuel lamp lights up.
11-08-2014 06:42 PM
seraniko what if your tank is full and cann't a hose to siphon out the gas, how do you empty the tank when its still installed?
02-21-2014 01:26 PM
syncro87 An interesting alternate method to dropping the tank. Not saying it's the proper way, but it works. Probably not the safest idea lol.

http://www.youtube.com/watch?v=97pJpRu-E4A

Sorry I bumped this. Meant to post elsewhere.
11-21-2013 09:37 PM
sootsme Also, there's a video on YouTube. Search "2000 Ford Focus fuel pump replacement"+" the easy way"
11-10-2013 09:06 AM
Bills86e just wipe with a rag to clean it. no need to grease it.
11-09-2013 09:12 PM
willysp I figured it out! I just turned it counter clockwise and it came loose.
now I am having a lot of trouble putting the blue ring back. any suggestions? I was thinking about using some grease...
11-09-2013 07:31 PM
willysp hi, I have a 2002 and I am replacing the fuel pump. This fuel pump is the one "without" the springs that keeps it in place. for some reason I can't take it out of the tank. I tried pulling, turning it and tried to find any clips holding it in place but I couldn't find anything.
Any suggestions?
thanks
Wilson
10-04-2013 05:11 PM
Bills86e What we need here is what tool to cut the metal, then how to place back to avoid cabin exposures from exhaust asphyxiation or gas under car explosion. Use safe judgement!
My guess is remove rear seat and find the electrical fuel pump relay to wires rubber gromment, pull-look thru, then have water hose sprayer close, use a battery metal cut saw with non-arcing blade, and cut 10" square. Do this in a safe open area, and no one near by, or near other flamable materials.
Do same at local Boneyard but 11" square with a notch path cut to center wire, to get on your wires to your pump. Only saw no more that 1/4" deep thru the metal. Use a fire rated cauk under all edges of new 11" square plate and screw it down with drill point stainless #8 x 3/8" long panhead screws every three inches around the perimeter, centered on your 10" hole..
The gas tank fuel module ring is simply lefty-loosey. Make a notch cut U in a wood 12" long 1 x 4 as a tool, if ya can't un-loosen the ring. The entire fuel pump module with its lift arm
float with come out carefully. Put the thing on your bench and dis-assemble to replace the pump itself, or fix your fuel float reader card..ect Take a picture of its orientation as you lift out. Don't
loose the rubber o-ring that seales the module cap, or cross-thread it screwing it back on.

Bills86e
This thread has more than 10 replies. Click here to review the whole thread.

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


All times are GMT -5. The time now is 08:30 AM.


Copyright 2002-2014 FocusFanatics.com. All Rights Reserved : Privacy Policy : Advertise Information

Focus Fanatics Ford Focus Forum offers many fun ways for you to engage with other Ford Focus Owners from across the world. Whether it be about the aftermarket performance modifications, technical how-to's, European tuned suspension or awesome fuel economy similar to the Audi S3, Ford Fusion and Acura TLX. You can find all Ford Focus and Focus ST related information here. Join our Ford Focus discussion forums and chat with local Focus enthusiasts in your area. Challenger Hellcat - Charger Hellcat