5 Minute throttle response/DCT solution? - Page 22 - Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum
Ford Focus Forum
HomeContact UsAbout UsGalleryDiscussion ForumsMarketplace


Go Back   Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum > Ford Focus Third Generation > MK3 Focus

MK3 Focus The place to chat about general questions, window tinting, exterior body, interior and lighting upgrades for the third generation 2012-Current Focus.

Search This Forum | Image Search | Advanced Search    
FocusFest FocusFanatics Merchandise

Reply




 
LinkBack Thread Tools Display Modes
Old 04-30-2014, 01:11 AM   #211
Focus Enthusiast
 
evilO's Avatar
 
Join Date: Sep 2013
Fan#: 118681
Location: Castle Pines, CO
What I Drive: 2014 Tuxedo Black Focus SE

Posts: 364
Points 1,442, Level 21
Points: 1,442, Level: 21 Points: 1,442, Level: 21 Points: 1,442, Level: 21
Level Up 43% Completed
Level up: 43% Level up: 43% Level up: 43%
Forum Activity 1%
Activity: 1% Activity: 1% Activity: 1%
FF Reputation: 2 evilO Good Standing Member
Buy-Sell-Trade Rating: (2)
Quote:
Originally Posted by bama_focus View Post
Had my gap taped for over 10k miles and I don't believe it has made any difference at all.
This. After installing a Steeds CAI I don't believe a gap would make one bit of difference. Tolerances in these vehicles just aren't that tight. Let alone a tolerance of air flow at the intake creating a vehicle that jerks, stutters, bogs, etc.
evilO is offline  
    Reply With Quote Quick reply to this message
Sponsored Links
Advertisement
 
Old 04-30-2014, 08:18 AM   #212
Focus Addict
 
Join Date: Apr 2012
Fan#: 97725
Location: Taylorsville, UT
What I Drive: 2012, Sonic Blue, Focus Titanium

Posts: 1,287
Points 4,437, Level 42
Points: 4,437, Level: 42 Points: 4,437, Level: 42 Points: 4,437, Level: 42
Level Up 44% Completed
Level up: 44% Level up: 44% Level up: 44%
Forum Activity 2%
Activity: 2% Activity: 2% Activity: 2%
FF Reputation: 1 raptor1956 Good Standing Member
Buy-Sell-Trade Rating: (0)
I just noticed this topic, don't know how I missed it this long...

One thing that might be at play here is a flexing as the engine is revved during acceleration causing whatever gap to open or close. If the gap was fixed there would seem to be less surging effect and only a reduction in power due to higher air temp, but if there is flexing then the ECU might have problems maintaining proper mixture due to rapid changes in air temp and air flow resistance.

The proper design would have had rubber boots to connect between the airbox and snorkel an clamped for better seal -- the design for this connection is pretty pathetic if you ask me.

I suspect I have minimal gap issues as I've had no performance issues like this, but I will investigate and see what gap I have. If I find a gap I'll likely use a rubbery tape so there's some compliance in case there is a flexing effect when the engine is revved.


Brian
__________________
2012 FF Ti HB Sonic Blue, Built 5/7/12, 401A + Parking Technology Package and MFT w/NAV 3.0.2 -> 3.2.2 -> 3.5.1 -> 3.6.2
raptor1956 is offline  
    Reply With Quote Quick reply to this message
Old 04-30-2014, 08:24 AM   #213
Focus Addict
 
Join Date: Feb 2012
Fan#: 95399
Location: somewhere, MA
What I Drive: Mazda-3 , formerly a focus SE

Posts: 832
Points 365, Level 7
Points: 365, Level: 7 Points: 365, Level: 7 Points: 365, Level: 7
Level Up 30% Completed
Level up: 30% Level up: 30% Level up: 30%
Forum Activity 15%
Activity: 15% Activity: 15% Activity: 15%
FF Reputation: 2 mr_cassandra Good Standing Member
Buy-Sell-Trade Rating: (0)
Quote:
Originally Posted by evilO View Post
This. After installing a Steeds CAI I don't believe a gap would make one bit of difference. Tolerances in these vehicles just aren't that tight. Let alone a tolerance of air flow at the intake creating a vehicle that jerks, stutters, bogs, etc.
many people here have closed that gap and reported significant improvement, but the question everyone needs to confront is why is everyone but the factory trying to fix the new car they are paying their hard-earned money for?
mr_cassandra is offline  
    Reply With Quote Quick reply to this message
Old 04-30-2014, 08:32 AM   #214
Focus Addict
 
Join Date: Oct 2012
Fan#: 105425
Location: the not-so-free state, MD
What I Drive: 2013 Ford Focus Titanium hatchback

Posts: 1,256
Points 1,664, Level 23
Points: 1,664, Level: 23 Points: 1,664, Level: 23 Points: 1,664, Level: 23
Level Up 64% Completed
Level up: 64% Level up: 64% Level up: 64%
Forum Activity 0%
Activity: 0% Activity: 0% Activity: 0%
FF Reputation: 6 slybarman Good Standing Member
Buy-Sell-Trade Rating: (0)
In the heat of summer it makes a noticeable difference. In cooler or winter months, not so much. Dan's theory was the engine was sucking in hot air from the engine compartment and it was screwing up the mixture/timing. Sounds plausible as anything to me.
__________________
MK3 Focus = a lot of good ideas rather poorly executed.
slybarman is offline  
    Reply With Quote Quick reply to this message
Old 04-30-2014, 08:33 AM   #215
Focus Addict
 
wavsine's Avatar
 
Join Date: Sep 2013
Fan#: 118470
Location: DFW, TX
What I Drive: 2013 Focus SE Oxford White Hatch 5m

Posts: 1,169
Points 22,777, Level 93
Points: 22,777, Level: 93 Points: 22,777, Level: 93 Points: 22,777, Level: 93
Level Up 43% Completed
Level up: 43% Level up: 43% Level up: 43%
Forum Activity 16%
Activity: 16% Activity: 16% Activity: 16%
FF Reputation: 17 wavsine Great Standing Member
Buy-Sell-Trade Rating: (0)
Quote:
Originally Posted by bama_focus View Post
Had my gap taped for over 10k miles and I don't believe it has made any difference at all.
The problem is that we don't know what size gap you had before you taped it. If you already had a relatively tight seal, then I would not expect any change.

The tolerances on these cars vary greatly. Dan knows his stuff and the theory behind the improvement is sound. Owners with a significant gap are drawing in warm air from under the hood.

In addition, the torque as you launch off the line may cause the motor to move and the gap may widen as you first take off.
__________________
Use a Motorcraft FL-400S filter to increase filtration media and oil quantity. (Drop in for FL-910S)

Synthetic oil in GDI engines
www.focusfanatics.com/forum/showthread.php?t=324396
wavsine is offline  
    Reply With Quote Quick reply to this message
Old 04-30-2014, 08:29 PM   #216
Focus Enthusiast
 
Join Date: Dec 2013
Fan#: 131129
Location: Dubuque, IA
What I Drive: 2014 Char Gray Ford Focus SE HB DCT

Posts: 73
Points 251, Level 5
Points: 251, Level: 5 Points: 251, Level: 5 Points: 251, Level: 5
Level Up 2% Completed
Level up: 2% Level up: 2% Level up: 2%
Forum Activity 0%
Activity: 0% Activity: 0% Activity: 0%
FF Reputation: 1 larz27 Good Standing Member
Buy-Sell-Trade Rating: (0)
I just did this today on a 2014. Put some black duct tape over the gap, sealed it up with the plastic wrap and I definitely noticed less jerky acceleration at low speeds and take off. It didn't cut my 0-60 in half, but this certainly helped me with a smoother ride especially at low speeds. The car drives like it should now. Honestly, I'm impressed by this literal patch. Seriously, this needs to be the first thing that pops up when people visit the mk3 thread for the first time. I've been around here for months and I've never seen this mentioned before. Sticky this stuff guys, or put it in the DIY section.
larz27 is offline  
    Reply With Quote Quick reply to this message
Old 04-30-2014, 11:19 PM   #217
Focus Rookie
 
Join Date: Mar 2014
Fan#: 149698
Location: Montreal, Quebec, Canada
What I Drive: 2013 Black Ford Focus Titanium

Posts: 9
FF Reputation: 1 Logos Good Standing Member
Buy-Sell-Trade Rating: (0)
My car always bogged down and was hesitant accelerating when coming to a stop after having exited the highway. I always wondered why it was only after driving on the highway!

Well, I checked my air inflow and my car has 4-5mm gap. Can't wait to tape it up and test it out! Thank you!
Logos is offline  
    Reply With Quote Quick reply to this message
Old 05-01-2014, 12:06 PM   #218
Focus Enthusiast
 
bama_focus's Avatar
 
Join Date: Aug 2013
Fan#: 117648
Location: birmingham, AL
What I Drive: 2012 focus sedan sel

Posts: 416
Points 266, Level 5
Points: 266, Level: 5 Points: 266, Level: 5 Points: 266, Level: 5
Level Up 32% Completed
Level up: 32% Level up: 32% Level up: 32%
Forum Activity 0%
Activity: 0% Activity: 0% Activity: 0%
FF Reputation: 2 bama_focus Good Standing Member
Buy-Sell-Trade Rating: (0)
How's this for throttle response? Put your foot down sooner.
__________________
2012 Focus SEL sedan tuxedo black
2005 GMC Envoy XUV
bama_focus is offline  
    Reply With Quote Quick reply to this message
Old 05-01-2014, 02:46 PM   #219
Focus Addict
 
Join Date: Oct 2012
Fan#: 105425
Location: the not-so-free state, MD
What I Drive: 2013 Ford Focus Titanium hatchback

Posts: 1,256
Points 1,664, Level 23
Points: 1,664, Level: 23 Points: 1,664, Level: 23 Points: 1,664, Level: 23
Level Up 64% Completed
Level up: 64% Level up: 64% Level up: 64%
Forum Activity 0%
Activity: 0% Activity: 0% Activity: 0%
FF Reputation: 6 slybarman Good Standing Member
Buy-Sell-Trade Rating: (0)
Quote:
Originally Posted by bama_focus View Post
How's this for throttle response? Put your foot down sooner.
Not so good.
__________________
MK3 Focus = a lot of good ideas rather poorly executed.
slybarman is offline  
    Reply With Quote Quick reply to this message
Old 05-02-2014, 04:24 PM   #220
Focus Fanatic
 
Jburks's Avatar
 
Join Date: Feb 2014
Fan#: 145009
Location: Vancouver, WA
What I Drive: 2014 Hatchback SE RR DCT "Fiona"

Posts: 1,909
Points 6,799, Level 54
Points: 6,799, Level: 54 Points: 6,799, Level: 54 Points: 6,799, Level: 54
Level Up 25% Completed
Level up: 25% Level up: 25% Level up: 25%
Forum Activity 99%
Activity: 99% Activity: 99% Activity: 99%
FF Reputation: 2 Jburks Good Standing Member
Buy-Sell-Trade Rating: (0)
So i decided to check and see if i had the gap on mine this morning. I have a 2014 SE. I pulled back the rubber flap and defintely had a noticable gap. I used some electrical tape to cover it up. I have only driven about ten miles since doing it so i havent seen a huge difference but will report back after i have put some more miles on it.
__________________
Green Filters drop in-Snorkel Delete-Steeda RSB-Fswerks RMM insert-Focus Power Tune.
Build thread-http://www.focusfanatics.com/forum/showthread.php?t=382642
Jburks is offline  
    Reply With Quote Quick reply to this message
Reply

Bookmarks & Social Networks

Tags
dct fix , powershift fix

Quick Reply
Message:
Options

Register Now

In order to be able to post messages on the Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Thread Tools
Display Modes

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On



All times are GMT -5. The time now is 05:11 AM.


Copyright 2002-2015 FocusFanatics.com. All Rights Reserved : Privacy Policy : Advertise Information

Focus Fanatics Ford Focus Forum offers many fun ways for you to engage with other Ford Focus Owners from across the world. Whether it be about the aftermarket performance modifications, technical how-to's, European tuned suspension or awesome fuel economy similar to the Mazda CX-3, Audi S3, Mazda MX-5 Miata and Acura TLX. You can find all Ford Focus, Focus ST and Focus RS related information here. Join our Ford Focus discussion forums and chat with local Focus enthusiasts in your area. If you own other makes have a look at Challenger Hellcat Forum, Charger Hellcat Forum, Cadillac ATS-V Forum, Cadillac ATS Forum, Cadillac CTS-V Forum, Lexus RC-F Forum, Lexus GS-F Forum, Mercedes GLA Forum, Mercedes GLE Forum and Volvo XC90 Forum.





Search Engine Optimization by vBSEO 3.6.1