I need help bad with zx3 half shaft - Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum
Ford Focus Forum
HomeContact UsAbout UsGalleryDiscussion ForumsMarketplace


Go Back   Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum > Ford Focus Tech Discussions > General Technical Chat

General Technical Chat This section is for technical discussions relating to general maintenance, electrical issues, engine trouble, and recalls.

Search This Forum | Image Search | Advanced Search    
FocusFest FocusFanatics Merchandise

Reply
 
LinkBack Thread Tools Display Modes
Old 05-25-2013, 12:54 AM   #1
Focus Jr. Enthusiast
 
Join Date: Feb 2012
Fan#: 95223
Location: Paramus, NJ
What I Drive: 2003 White ZX3

Posts: 47
Points 528, Level 10
Points: 528, Level: 10 Points: 528, Level: 10 Points: 528, Level: 10
Level Up 56% Completed
Level up: 56% Level up: 56% Level up: 56%
Forum Activity 2%
Activity: 2% Activity: 2% Activity: 2%
FF Reputation: 1 chrisdr Good Standing Member
Buy-Sell-Trade Rating: (0)
I need help bad with zx3 half shaft

my drivers side inner cv joint basically blew up today after 500 mile trip first began with a scratching sound some vibration on the automatic trans shifter then all hell brakes loose.got home looked at it bearings where apart inside boot
Pulled the shaft out and and the piece with the splines stayed inn pulled out with one yank with vice grips attached . had previously bought the half shaft from pep boys.It is a Carrdone.They replaced it for me go to put it in the tranny and it will not go in at all.return it again get another one will not go in no matter what i do. Go to advance auto get one there it will not slide in up to the circle clip where i would normally give a good whack with a piece of wood and small sledge hammer to get it to seat.So now I have no Idea what to do,
HELP any one please.I can put everything back together so if it has to be towed but i can brake down everything including removing the strut in about 10 minutes

Im competent but need you guys who are the real experts to help me out.


chrisdr is offline  
    Reply With Quote Quick reply to this message
Sponsored Links
Advertisement
 
Old 05-25-2013, 01:13 AM   #2
FF's Night Security
 
sleepyboy's Avatar
 
Join Date: Nov 2004
Fan#: 15335
Location: SW Houston, TX, United States
What I Drive: 01' Yellow ZX3 euro, 04' ZX5 SVT

Posts: 27,420
Points 146,930, Level 100
Points: 146,930, Level: 100 Points: 146,930, Level: 100 Points: 146,930, Level: 100
Level Up 0% Completed
Level up: 0% Level up: 0% Level up: 0%
Forum Activity 100%
Activity: 100% Activity: 100% Activity: 100%
FF Reputation: 51 sleepyboy Excellent Standing Member
Buy-Sell-Trade Rating: (11)
I'd try another axle and I'd also make sure they are giving me the correct, they could be giving a wrong one .
__________________
I started out with nothing and I still have most of it left

Hatch Nation #15 (Ole' Yeller') & #150 (The SVT)
Moderator for
Technical Chat
Zetec Performance Chat
Southern Fanatics Chat
sleepyboy is online now  
    Reply With Quote Quick reply to this message
Old 05-25-2013, 01:38 AM   #3
Focus Fanatic
 
elsolo's Avatar
 
Join Date: Mar 2012
Fan#: 96835
Location: Long Beach, CA
What I Drive: 2003 dark shadow grey metallic ZX3

Posts: 2,365
Points 2,695, Level 31
Points: 2,695, Level: 31 Points: 2,695, Level: 31 Points: 2,695, Level: 31
Level Up 64% Completed
Level up: 64% Level up: 64% Level up: 64%
Forum Activity 3%
Activity: 3% Activity: 3% Activity: 3%
FF Reputation: 17 elsolo Great Standing Member
Buy-Sell-Trade Rating: (1)
What's the part number on the box, look that up yourself to see if that is right for your application.

One has has 23 splines, other has 26 splines, depends on which transmission.
(based off the data linked below)
http://www.autozone.com/autozone/par.../N-jk8uwZ6o2dc
elsolo is offline  
    Reply With Quote Quick reply to this message
Old 05-25-2013, 01:49 AM   #4
Focus Jr. Enthusiast
 
Join Date: Feb 2012
Fan#: 95223
Location: Paramus, NJ
What I Drive: 2003 White ZX3

Posts: 47
Points 528, Level 10
Points: 528, Level: 10 Points: 528, Level: 10 Points: 528, Level: 10
Level Up 56% Completed
Level up: 56% Level up: 56% Level up: 56%
Forum Activity 2%
Activity: 2% Activity: 2% Activity: 2%
FF Reputation: 1 chrisdr Good Standing Member
Buy-Sell-Trade Rating: (0)
looked up from cardonne which is what was in there and it matches the one they gave me.I bought secound one from autozone, no luck.checked orillies and everything says i have the right ones but they dont come close to sliding in.checked circle clips they are in the rite shape so i cant figure out why they wont slide in
chrisdr is offline  
    Reply With Quote Quick reply to this message
Old 05-25-2013, 02:07 AM   #5
Focus Enthusiast
 
Join Date: Jun 2008
Fan#: 57310
Location: Cairo, WV
What I Drive: 2002 silver ZX5

Posts: 101
Points 449, Level 8
Points: 449, Level: 8 Points: 449, Level: 8 Points: 449, Level: 8
Level Up 98% Completed
Level up: 98% Level up: 98% Level up: 98%
Forum Activity 0%
Activity: 0% Activity: 0% Activity: 0%
FF Reputation: 1 burnie Good Standing Member
Buy-Sell-Trade Rating: (0)
half shaft

First thing I`d try now is seeing if the original will go back on . Just my 2 cents worth
burnie is offline  
    Reply With Quote Quick reply to this message
Old 05-25-2013, 06:15 AM   #6
Focus Fanatic
 
Join Date: Mar 2012
Fan#: 96610
Location: Fort Worth, TX
What I Drive: 00 wagon, 02 sedan both zetec atx

Posts: 6,943
Points 4,030, Level 40
Points: 4,030, Level: 40 Points: 4,030, Level: 40 Points: 4,030, Level: 40
Level Up 40% Completed
Level up: 40% Level up: 40% Level up: 40%
Forum Activity 100%
Activity: 100% Activity: 100% Activity: 100%
FF Reputation: 34 amc49 Great Standing Member
Buy-Sell-Trade Rating: (0)
Should'a been looking close at the old stub that came out. That is the cure for your trouble.
amc49 is online now  
    Reply With Quote Quick reply to this message
Old 05-25-2013, 04:33 PM   #7
Focus Enthusiast
 
Join Date: Jan 2013
Fan#: 108093
Location: Portland, OR
What I Drive: 2001 Red Focus SE Street Edition

Posts: 302
Points 241, Level 4
Points: 241, Level: 4 Points: 241, Level: 4 Points: 241, Level: 4
Level Up 82% Completed
Level up: 82% Level up: 82% Level up: 82%
Forum Activity 2%
Activity: 2% Activity: 2% Activity: 2%
FF Reputation: 2 tmittelstaedt Good Standing Member
Buy-Sell-Trade Rating: (0)
When you say it won't go in are you meaning that it slides all the way in but you can't get it to snap in the very last quarter inch or so? Or do you mean that you cannot even get it to enter into the hole?

Have you looked into the hole and counted the number of splines, and made sure the hole is aligned?
tmittelstaedt is offline  
    Reply With Quote Quick reply to this message
Old 05-25-2013, 07:13 PM   #8
Focus Fanatic
 
Join Date: Mar 2012
Fan#: 96610
Location: Fort Worth, TX
What I Drive: 00 wagon, 02 sedan both zetec atx

Posts: 6,943
Points 4,030, Level 40
Points: 4,030, Level: 40 Points: 4,030, Level: 40 Points: 4,030, Level: 40
Level Up 40% Completed
Level up: 40% Level up: 40% Level up: 40%
Forum Activity 100%
Activity: 100% Activity: 100% Activity: 100%
FF Reputation: 34 amc49 Great Standing Member
Buy-Sell-Trade Rating: (0)
'it will not go in at all'

'it will not slide in up to the circle clip'

Betting wrong spline part or spline ends chewed up.
amc49 is online now  
    Reply With Quote Quick reply to this message
Reply

Bookmarks & Social Networks

Quick Reply
Message:
Options

Register Now

In order to be able to post messages on the Ford Focus Forum, Ford Focus ST Forum, Ford Focus RS Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:
What I Drive
Year, color, and model of your car. Example: 2003 Pitch Black ZX3
Name
Your real name.
City
State
Country
Insurance
Please select your insurance company (Optional)

Log-in

Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.



Thread Tools
Display Modes

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On



All times are GMT -5. The time now is 01:15 PM.


Copyright 2002-2015 FocusFanatics.com. All Rights Reserved : Privacy Policy : Advertise Information

Focus Fanatics Ford Focus Forum offers many fun ways for you to engage with other Ford Focus Owners from across the world. Whether it be about the aftermarket performance modifications, technical how-to's, European tuned suspension or awesome fuel economy similar to the Mazda CX-3, Audi S3, Mazda MX-5 Miata and Acura TLX. You can find all Ford Focus, Focus ST and Focus RS related information here. Join our Ford Focus discussion forums and chat with local Focus enthusiasts in your area. If you own other makes have a look at Challenger Hellcat Forum, Charger Hellcat Forum, Cadillac ATS-V Forum, Cadillac ATS Forum, Cadillac CTS-V Forum, Lexus RC-F Forum, Lexus GS-F Forum, Mercedes GLA Forum, Mercedes GLE Forum, Civic Type-R Forum and Volvo XC90 Forum.





Search Engine Optimization by vBSEO 3.6.1